Few flights resume at Chicago airports after fire

Before you go, we thought you'd like these...
Before you go close icon

17 PHOTOS
Chicago O'hare fire - flights canceled -- updated 10/01/2014
See Gallery
Few flights resume at Chicago airports after fire
A flight departure board at O'Hare International Airport in Chicago still shows some cancelled flights Monday, Sept. 29, 2014. The Federal Aviation Administration said Monday it is reviewing security practices and how it deals with unexpected incidents throughout its air traffic control facilities following last week's fire at a Chicago-area air traffic facility. (AP Photo/Teresa Crawford)
A traveler waits in line Monday, Sept. 29, 2014 at O'Hare International Airport in Chicago. The Federal Aviation Administration said Monday it is reviewing security practices and how it deals with unexpected incidents throughout its air traffic control facilities following last week's fire at a Chicago-area air traffic facility. (AP Photo/Teresa Crawford)
A traveler looks at a flight departure board Monday, Sept. 29, 2014 at O'Hare International Airport in Chicago. The Federal Aviation Administration said Monday it is reviewing security practices and how it deals with unexpected incidents throughout its air traffic control facilities following last week's fire at a Chicago-area air traffic facility. (AP Photo/Teresa Crawford)
Dennis McCormack of Rockaway, N.J. checks the departure board only to find out that his flight to Newark, N.J. has been canceled at O'Hare International Airport in Chicago, Friday, Sept. 26, 2014. All flights in and out of Chicago's two airports were halted Friday after a fire at a suburban air traffic control facility sent delays and cancellations rippling through the U.S. air travel network. Authorities said the blaze was intentionally set by a contract employee of the Federal Aviation Administration and had no ties to terrorism. (AP Photo/Paul Beaty)
Ann Walden and her 15 month-old daughter Delphine wait in-line after their flight to Baton Rouge was delayed at O'Hare International Airport in Chicago, Friday, Sept. 26, 2014. All flights in and out of Chicago's two airports were halted Friday after a fire at a suburban air traffic control facility sent delays and cancellations rippling through the U.S. air travel network. Authorities said the blaze was intentionally set by a contract employee of the Federal Aviation Administration and had no ties to terrorism. (AP Photo/Paul Beaty)
Dennis McCormack of Rockaway, N.J. checks the departure board only to find out that his flight to Newark, N.J. has been canceled at O'Hare International Airport in Chicago, Friday, Sept. 26, 2014. All flights in and out of Chicago's two airports were halted Friday after a fire at a suburban air traffic control facility sent delays and cancellations rippling through the U.S. air travel network. Authorities said the blaze was intentionally set by a contract employee of the Federal Aviation Administration and had no ties to terrorism. (AP Photo/Paul Beaty)
Kanna Ortiz 4, waits in a line after her flight back home to New Jersey was delayed at O'Hare International Airport in Chicago, Friday, Sept. 26, 2014. All flights in and out of Chicago's two airports were halted Friday after a fire at a suburban air traffic control facility sent delays and cancellations rippling through the U.S. air travel network. Authorities said the blaze was intentionally set by a contract employee of the Federal Aviation Administration and had no ties to terrorism. (AP Photo/Paul Beaty)
Breanne Eging checks on her flight to Greenville, South Carolina at O'Hare International Airport in Chicago, Friday, Sept. 26, 2014. All flights in and out of Chicago's two airports were halted Friday after a fire at a suburban air traffic control facility sent delays and cancellations rippling through the U.S. air travel network. Authorities said the blaze was intentionally set by a contract employee of the Federal Aviation Administration and had no ties to terrorism. (AP Photo/Paul Beaty)
A fire at the FAA's Chicago Center, in suburban Aurora, has halted all air traffic in or out of major airports in Chicago and Detroit. (WGN)
This view of air traffic over the United States shows a virtual hole in the sky over Chicago. (FlightRadar24)
A fire truck seen earlier Friday morning at the burning building. (WGN)
Employees seen outside the facility after being evacuated. (WGN)
The Chicago Center seen from the air. (WGN)
There is virtually no air traffic over Chicago, home to both O'Hare International (the world's busiest airport) and Midway Airport. (FlightAware)
A United Airlines jet takes off from O'Hare International Airport on September 19, 2014 in Chicago, Illinois. In 2013, 67 million passengers passed through O'Hare, another 20 million passed through Chicago's Midway Airport, and the two airports combined moved more than 1.4 million tons of air cargo. (Photo by Scott Olson/Getty Images)
Ann Walden checks her phone as 15 month-old daughter Delphine plays while waiting in-line after their flight to Baton Rouge was delayed at O'Hare International Airport in Chicago, Friday, Sept. 26, 2014. All flights in and out of Chicago's two airports were halted Friday after a fire at a suburban air traffic control facility sent delays and cancellations rippling through the U.S. air travel network. Authorities said the blaze was intentionally set by a contract employee of the Federal Aviation Administration and had no ties to terrorism. (AP Photo/Paul Beaty)
of
SEE ALL
BACK TO SLIDE
SHOW CAPTION +
HIDE CAPTION

By JASON KEYSER

CHICAGO (AP) - A contract employee suspected of setting a fire at a suburban Chicago air traffic control center brought two of the nation's busiest airports to a halt for hours Friday, sending delays and cancellations rippling through the air-travel network from coast to coast.

Authorities quickly ruled out any ties to terrorism, but the ground stoppage at O'Hare and Midway airports immediately raised questions about whether the Federal Aviation Administration has adequate backup plans to keep planes moving when a single facility has to shut down.

By midday, nearly 1,800 flights in and out of Chicago alone had been canceled, and more cancellations were expected. A few flights began taking off and landing again after a nearly five-hour gap. But the planes were moving at a much-reduced pace, officials said, and no one could be sure when full service would resume.

Investigators had no immediate information on a possible motive and emphasized that the FAA contractor was authorized to be at the site.

The early morning fire forced the evacuation of the control center in Aurora, about 40 miles west of downtown Chicago. It was the second unexpected shutdown of a Chicago-area air-traffic facility since May.

Emergency crews found the man suspected of setting the fire in the basement, where the blaze began, with multiple self-inflicted knife wounds as well as burns to his body, said Thomas Ahern, a spokesman for the Bureau of Alcohol, Tobacco, Firearms and Explosives, which was taking part in the investigation. He was taken to a hospital and was expected to survive.

The man used gasoline as an accelerant, and there was fire damage to some wiring in the building, as well as water damage from the sprinkler system, Ahern said. Authorities were preparing to search the suspect's home in nearby Naperville. No charges have been filed, and authorities refused to release his name.

Another employee of the facility was treated at the scene for smoke inhalation. The flames were extinguished by 7 a.m., according to Aurora spokesman Dan Ferrelli.

When the center was evacuated, management of the region's airspace was transferred to other facilities, FAA spokeswoman Elizabeth Cory said.

But hours after the ordeal began, the region's air traffic was still a mess. The Aurora facility - which had become a crime scene - remained shut down while investigators scoured the site.

A control center in Indianapolis called in staff on overtime to patch together inbound and outbound routes for the Chicago area, said Douglas Church, a spokesman for the National Air Traffic Controllers Association labor union. But the process was slow and painstaking because there was no way for other Chicago-area controllers to send flight plans to computers in Indianapolis. That information normally gets routed through the Aurora facility.

"They have had to revert to entering flight-plan information on those aircraft into (their) system by hand," Church wrote in an email.

That led some observers to call for better backup plans.

"This is a nightmare scenario when we thought systems were in place to prevent it," said aviation analyst Joseph Schwieterman of DePaul University in Chicago. "Technology is advancing so fast that ... there's less of a need for air traffic control to be so geographically oriented. I think the FAA's going to find itself under a microscope."

The disruption was also likely to deliver a financial hit to airlines, Schwieterman said.

An FAA spokeswoman in Chicago did not respond to a request for comment about the agency's backup planning.

The shutdown quickly spread travel misery around the country, with airports as close as Milwaukee and as far as Dallas canceling flights. Online radar images showed a gaping hole in the nation's air-traffic map over the upper Midwest.

Passengers already in the air who thought they were going to Chicago wound up elsewhere. Flight-tracking services showed some Chicago-bound American flights doing loops over Michigan before diverting to Detroit.

Southwest Airlines said it was scrapping all of its flights at Midway and Milwaukee for the entire day.

At O'Hare, long lines formed at ticket counters, and some passengers simply gave up and returned home.

Brothers Glenn and Gary Campbell, of suburban Chicago, had planned to travel to the Orlando, Florida, area to attend their father's 80th birthday party. Instead, they settled for refunds.

"That it is so easy to disrupt the system is disturbing," said Gary Campbell, a carpenter from Crystal Lake, Illinois. "They need to see how to make sure this kind of thing doesn't happen again."

In May, an electrical problem forced the evacuation of a regional radar facility in suburban Elgin. A bathroom exhaust fan overheated and melted insulation on some wires, sending smoke through the facility's ventilation system and into the control room.

That site was evacuated for three hours, and more than 1,100 flights were canceled.

The Aurora facility, known as an enroute center, handles aircraft flying at high altitudes, including those approaching or leaving Chicago airports. Air traffic closer to the airports is handled by a different facility and by the control towers located at the airfields.

A computer glitch at a similar facility on the West Coast in April forced a 45-minute shutdown at Los Angeles' largest airport.


More from AOL:
Stewart unsure if he'll race sprint cars again
3 killed as Somali pirates fight over ransom
Jeter shows he's human in dramatic Yankee Stadium finale

Read Full Story

Sign up for Breaking News by AOL to get the latest breaking news alerts and updates delivered straight to your inbox.

Subscribe to our other newsletters

Emails may offer personalized content or ads. Learn more. You may unsubscribe any time.

From Our Partners